A method for reducing parasite drag of medium transport helicopter

Mykhaylo Kybalnyy, Oleksii Prytula, Sergii Degtiarenko, Kateryna Izviekova

Abstract


At present, more and more stringent emission requirements are being imposed on helicopters. Carbon dioxide emissions are a function of fuel consumption, and fuel consumption is directly dependent on the power required for a helicopter cruise flight. The power, required for horizontal flight of a helicopter directly depends on the design of the fuselage and other non-lifting elements, and accordingly, on parasite drag. Therefore, the desire to reduce parasite drag is expected and understandable. Helicopter parasite drag reduction was hailed as one of the key topics of the Seventh Clean Sky Framework Conference. For sixty years of research on this topic, a tremendous amount of experience has been accumulated. In particular, it was found that the main contributors to the total parasite drag of the helicopter were the main rotor hub and swashplate. The subject matter of this article is the study of the parasite drag of the hub and swashplate of a medium passager/transport helicopter Mi-8/17. This study aimed to develop methods to reduce the parasite drag of the Mi-8/17 helicopter. Mi-8/17 is the most mass-produced twin-engine helicopter in the world. Currently, more than 4,5 thousand units are in operation around the world. Therefore, the task of reducing parasite drag for this helicopter is very relevant. Modern methods of computation fluid dynamics (CFD) are used. Modern methods of computational fluid dynamics with an acceptable degree of accuracy make it possible to consider the interference phenomena of the components of the hub, swashplate, and helicopter fuselage, which is not always possible, to obtain correctly during expensive wind tunnel tests. During the work, the following results were obtained. An analysis was made of the contribution of each element of the design of the hub and the main rotor swashplate to the total parasite drag. A method for reducing the parasite drag of a helicopter using a mast fairing is proposed. Several variants of the mast fairing were considered, and the most effective one was chosen. The effect, as well as its degree of influence, of the airflow blown by the fan cooling the air-oil radiators, on the general parasite drag of the helicopter was revealed. The results of the studies, given in this article have been implemented in the production.

Keywords


helicopter; rotor swashplate; parasite drag; CFD; fairing; numerical simulation; Mi-8/17

Full Text:

PDF

References


Gibertini, G., Zanotti, A., Droandi, G., Grassi, D., Campanardi, G., Auteri, F., Aceti, A. and Le Pape, A. Wind-tunnel tests of a heavy-class helicopter optimised for drag reduction. The Aeronautical Journal, Cambridge University, 2016, vol. 120, iss. 1231, pp. 1446-1447. DOI: 10.1017/aer.2016.60.

Desvigne, D. and Alfano, D. Rotor-head/ fuselage interactional effects on helicopter drag: influence of complexification of the rotor head geometry. 39th European Rotorcraft Forum, 2013, pp. 60-64.

Bridgeman, J. O. and Lancaster, G. T. Predicting Hub Drag on Realistic Geometries. American Helicopter Society Aeromechanics Specialists’ Conference, 2010, pp. 2008-2031.

Sheehy, T. and Clark, D. R. Method for Predicting Helicopter Hub Drag. United Technologies Corporation Report Nr. AD-A021201, 1976. 109 p. DOI: 10.21236/ada021201.

Sheehy, T. W. A General Review of Helicopter Rotor Hub Drag Data. Journal of the American Helicopter Society, 1977, vol. 22, iss. 2, pp. 2-10. DOI: 10.4050/JAHS.22.2.2

Reich, D. B., David, B., Krane, M. H., Willits, S. M. and Schmitz, S. Full-Scale Reynolds Number Testing of Rotor Hub Drag and Wake Turbulence. Journal of the American Helicopter Society, 2022, vol. 67, iss. 4, pp. 1-10. DOI: 10.4050/JAHS.67.042008.

Graham, D. R., Sung, D. Y., Young, L. A., Louie, A. W. and Stroub, R. H. Helicopter Hub Fairing and Pylon Interference Drag, NASA Technical Memorandum 101052, 1989. 187 p.

Young, L. A., Graham, D. R. and Strob, R. H. Experimental Investigation of Rotorcraft Hub and Shaft Fairing Drag Reduction. Journal of Aircraft, 1987, vol. 24, iss. 12, pp. 861-687. DOI: 10.2514/3.45530.

Kybalnyy, M., Dyomin, A., Degtjarenko, S. and Moscalenko, M. Rozrakhunkove doslidzhennya aerodynamichnykh kharakterystyk rul’ovoho hvynta vertol’ota typu Mi-8 z urakhuvannyam interferentsiyi z nesuchym hvyntom na rezhymi vysinnya pry bokovomu vitri [Computational study of aerodynamic characteristics of the Mi-8 type helicopter’s tail rotors on the hovering with crosswind taking into account main rotor interaction]. Aviacijno-kosmicna tehnika i tehnologia – Aerospace technic and technology, 2021, no. 2, pp. 28-35. DOI: 10.32620/aktt.2021.2.04.

Petreski, D., Iliev, A., Trajanovska, E., Gjurov, L. and Petrovski, A. Improved technical characteristics of the MI-8/17 in the army of FYR Macedonia. Vojnotehnicki glasnik, 2018, vol. 66, iss. 1, pp. 122-142. DOI: 10.5937/vojtehg66-14520.

Pölzlbauer, P., Kümmel, A., Desvigne, D. and Breitsamter, C. Numerical Investigation of an Optimized Rotor Head Fairing for the RACER Compound Helicopter in Cruise Flight. Aerospace, 2021, vol. 8, iss. 3, article no. 66, pp. 2-21. DOI: 10.3390/aerospace8030066.

Khier, W. Computational Investigation of Advanced Hub Fairing Configurations to Reduce Heli-copter Drag. Proceedings of the 40th Annual European Rotorcraft Forum, 2014, pp. 1023-1033 DOI: 10.13140/2.1.1064.5443.

Kybalnyy, M., Prytula, O., Izviekova K. and Degtiarenko, S. Numerical study of the main rotor hub and swashplate parasite drag estimation of a medium transport helicopter. Proceedings of the 7th International Scientific and Practical Conference “Current Issues and Prospects for the development of Scientific Research”, Orleans, France, April 19-20 2023, 2023, vol. 32, Iss. 151, pp. 378-385. DOI: 10.51582/interconf.19-20.04.2023.039.

Dvigatel' TV3-117. Rukovodstvo po tekhnicheskoi ekspluatatsii [Engine TV3-117. Operation manual]. Kn. 3, izd. No. 48174/4, 1988. 116 p.

Vertolet Mi-8. Tekhnicheskoe opisanie. Kniga 1. Letno-tekhnicheskie kharakteristiki [Mi-8 helicopter. Technical description. Book 1. Flight performance]. Vneshtorgizdat Publ., 2000. 58 p.




DOI: https://doi.org/10.32620/aktt.2023.2.05